Rockwell B-1 Lancer

The B-1 Lancer is an American long-range strategic bomber. The B-1B version has been in service with the United States Air Force (USAF) since 1986. Together with the B-52 Stratofortress and the B-2 Spirit, it is the backbone of the United States's long-range bomber force.

History

The B-1 was conceived as the Advanced Manned Strategic Aircraft (AMSA) program circa 1965. AMSA was the last in a series of programs through the 1960s that looked at replacing the B-52 Stratofortress with a multi-role aircraft capable of long-range bombing and missile launching with nuclear weapons.

Background

Prior to the B-1 program the last US bomber project was the B-70 Valkyrie, an aircraft designed to fly at very high speeds in order to avoid air defenses. At the time these consisted of interceptor aircraft with fairly short ranges and flight times. A B-70 attacking Moscow crossing the northern border of the USSR near Arkhangelsk would be over land for only 30 minutes to cross the 615 mile distance at its cruising speed of 2,000 mph. This made the problem of launching and guiding the fighters to an interception extremely difficult, and it was believed the aircraft would fly right by most defenders.

The introduction of anti-aircraft missiles rendered this mode of operation dangerous; in order to maintain its high speed the aircraft had to fly at high altitudes, which allowed missile sites more than enough time to track and attack the B-70. For instance, the SA-2 Guideline's primary search radar had a nominal range of 170 miles. This would give the operators about five minutes warning, more than enough to launch an attack. The Valkyrie program was eventually cancelled by President Kennedy largely for these reasons, and the aircraft were used for test vehicles.

Air planners looked to low-altitude penetration as the solution to this problem. Radar is line-of-sight, so flying close to the ground and carefully selecting approaches it was possible to fly right by most defensive sites. The targets themselves often had defenses located nearby to prevent this sort of approach, but stand-off weapons like cruise missiles and AGM-69 SRAM allowed attack from outside the defensive missile's range. Low-altitude flight also made the bombers very difficult to detect from aircraft at higher altitudes, including interceptors, as radar systems of that generation could not "look down" due to the clutter of the ground reflections. On the downside, flying at low altitudes consumes much more fuel, so this approach demanded extremely long overall range.

Strategic attack was only one of several roles a bomber could be expected to be called on to provide. The B-52 was also an excellent "bomb truck" in the conventional role, notably in its modified "big belly" versions that increased bombload. With improved coordination with ground spotters, three-plane formations had proven to be superb ground-attack weapons during the Vietnam War. The same was not true of the Valkyrie, which would have had limited uses in the conventional bombing role and featured a much smaller bomb-load than the B-52, at 25,000 pounds.

AMSA

Although the B-52 Stratofortress was already filling both of these roles, by the early 1960s the state of the art in engine and airframe design had improved considerably. Even an aircraft designed simply to match the B-52's strategic capabilities would nevertheless end up being much more advanced. The Air Force studied various solutions through the 1960s that took these considerations into account in the development of a new bomber.

The first such study was known as the Subsonic Low Altitude Bomber (SLAB), which was completed in 1961. This was followed by the similar Extended Range Strike Aircraft (ERSA), which added a variable geometry wing planform, something then very much in vogue in the aviation industry. ERSA envisioned a relatively small aircraft with a 10,000 lb load and a range of 8,750 nautical miles, with 2,500 nm being flown at low altitudes. In August 1963 the similar Low-Altitude Manned Penetrator (LAMP) design was completed, which called for an aircraft with a 20,000 lb load and somewhat shorter range of 7,150 miles.

These all culminated in the October 1963 Advanced Manned Precision Strike System (AMPSS), which led to industry studies at Boeing, General Dynamics, and North American. In mid-1964, the USAF had revised its requirements and retitled the project as Advanced Manned Strategic Aircraft (AMSA), which differed from AMPSS primarily in that it also demanded a high-speed high-altitude capability, albeit slower than the Valkyrie at about Mach 2. Rockwell engineers joked that the new name actually stood for "America's Most Studied Aircraft", given the lengthy series of design studies.

First cancellation

The ending of the B-70 project had also led some to question the need for a newer aircraft in the strategic bombing role at all. The Air Force was adamant about retaining bombers as part of the nuclear "Triad" concept that included bombers, SLBMs and ICBMs in a combined package that complicated the defense. But the arguments for keeping the bombers was hotly debated. The original argument was that the bombers could be kept in the air during times of increased defensive posture, where they would be difficult to attack. Missiles of the era, like the Atlas and Redstone, required a lengthy fueling procedure immediately before launch, and were therefore vulnerable to air attack while still on the ground. They also had low accuracy, enough to attack cities as a strategic deterrent, but not enough to attack hardened military targets.

In the early 1960s newer generations of missiles with solid rocket motors were being introduced that could be launched quickly, faster than bombers, and were sited in underground silos for protection. Sneak attacks on these weapons would be very difficult for the USSR, which also lacked the accuracy in their own weapons and would have to use their own bombers in order to be effective against them. Accuracy was so improved that direct attacks against similar weapons in the USSR was a real possibility. Making matters more troublesome for the Air Force was the introduction and rapid improvement of the US Navy's SLBM force, which had considerably better survivability than either bombers or hardened missile silos. After this period the Air Force used a number of different arguments to make its case for the strategic bomber, including the conventional role and "recall-ability", but these arguments were much less convincing.

One of the biggest critics of the bomber portion of the Triad was Secretary of Defense Robert McNamara who preferred ICBMs over bombers for the Air Force side of the deterrent force. In testimony before Congress, McNamara said, "The strategic missile forces for 1967-71 will provide more force than is required for 'Assured Destruction' ... a new advanced strategic aircraft does not at this time appear justified." His opposition led to the program being stopped in 1964. The program was revived only a few years later however, and in 1968 an advanced development contract was issued to IBM and North American Rockwell. McNamara remained opposed to the program in favor of upgrading the existing B-52 fleet, and adding just under 300 FB-111s for shorter range roles then being filled by the B-58 Hustler. He vetoed the AMSA program and cancelled it once again.

B-1A program

President Nixon re-established the program after taking office, in keeping with his flexible response strategy that required a broad range of options short of general nuclear war. Secretary of Defense Melvin Laird reviewed the programs and decided to lower the numbers of FB-111s claiming it lacked the required range, and recommended that the AMSA design studies be accelerated. In April 1969 the program officially became the B-1A. This was the first entry in the new bomber designation series, first created in 1962.

After the prolonged development period, the production contract was finally awarded in 1970. The original program called for 2 test airframes, 5 flyable aircraft, and 40 engines. This was cut in 1971 to one ground test aircraft and 3 flight test articles (74-0158 through 0160). First flight was set for April 1974. The company changed its name to Rockwell International and named its aircraft division North American Aircraft Operations in 1973. A fourth prototype (76-1074) was ordered in the FY 1976 budget. This fourth plane was to be built to production standards. At one time, some 240 B-1As were to be built, with initial operational capability set for 1979.

Rockwell's design featured a number of features common to 1960s US designs. These included the use of variable geometry wings in order to provide both high lift during takeoff and landing, and low drag during a high-speed dash phase. Penetration of the USSR's defenses would take place in a dash, crossing them as quickly as possible before entering into the less defended "heartland" where speeds could be reduced again. The large size and fuel capacity of the design would allow this dash portion of the flight to be relatively long. Crew escape was provided for using an escape pod that ejected a portion of the entire cockpit with both pilots inside, as opposed to the more conventional ejection seats; it was felt that egress during a high-speed, high-altitude dash would be too dangerous without pressurization.

In order to achieve the required Mach 2 performance at high altitudes, the air intake inlets were variable. In addition, the exhaust nozzles were fully variable. Initially, it had been expected that a Mach 1.2 performance could be achieved at low altitude, which required that titanium be used in critical areas in the fuselage and wing structure. However, this low altitude performance requirement was lowered to only Mach 0.85, reducing the amount of titanium, and the overall cost.

An extensive suite of electronics was planned, including a Litton LN-15 inertial navigation system, a Doppler radar altimeter, a Hughes forward-looking infrared, a General Electric APQ-114 forward-looking radar and a Texas Instruments APQ-146 terrain-following radar. The terrain-following radar, in particular, would allow the B-1 to fly at much lower altitudes during the "dash" phase of the mission than the B-52, which relied on older systems that demanded higher minimum altitudes during bad weather.

The B-1A mockup review occurred in late October 1971. There were 297 requests for alterations. The first of four prototype B-1A models (s/n 74-158) flew on December 23, 1974. As the program continued the per-unit cost continued to rise. In 1970, the estimated per-unit price was $40 million, and by 1972, the cost had risen slightly to $45.6 million. By 1975, this number had climbed to $70 million.

In 1976 Viktor Belenko defected to Japan with his MiG-25 Foxbat. During debriefing he described a new "super-Foxbat" that had look-down/shoot-down radar systems in order to attack cruise missiles. This would also make any low-level penetration aircraft "visible" and easy to attack. Countering this problem would require another upgrade to the electronics suite, already one of the most complex and expensive ever fitted. The debate over the need for the bomber opened anew, and this time the reduced low-speed dash was a particular target. Given the performance and the armament suite that was similar to the B-52, the program was increasingly questioned as a very expensive solution that appeared to have limited benefits over the existing fleet.

The program remained highly controversial. In particular, Senator William Proxmire continually derided it in public, arguing it was an outlandishly expensive dinosaur. During the 1976 federal election campaign, Jimmy Carter made it one of the Democratic Party's platforms, saying "The B-1 bomber is an example of a proposed system which should not be funded and would be wasteful of taxpayers' dollars."

Another cancellation

When Carter took office in 1977 he ordered a review of the entire program. By this point the projected cost of the program had risen to over $100 million per aircraft, although this was lifetime cost over twenty years. He was informed of the relatively new work on stealth aircraft that had started in 1975, and decided that this was a far better avenue of approach than the B-1. Pentagon officials also stated that the ALCM launched from the existing B-52 fleet would give the USAF equal capability of penetrating Soviet airspace. With a 1500 mile range, the ALCM could be launched well outside the range any of Soviet defenses, and penetrate at low altitude just like a bomber, but in much greater numbers. A program to improve the B-52 and develop and deploy the ALCM would cost perhaps 20% of the price to deploy the planned 244 B-1A's.

On 30 June 1977 Carter announced that the B-1A would be cancelled, in favor of ICBMs, SLBMs, and a fleet of modernized B-52s armed with ALCMs. Carter called it "one of the most difficult decisions that I've made since I've been in office." No mention of the stealth work was made public, the program being top secret, but today it is known that he started the Advanced Technology Bomber (ATB) project in early 1978, which eventually led to the B-2 Spirit.

Reaction to the cancellation was unsurprisingly split along partisan lines. Robert Dornan claimed "They're breaking out the vodka and caviar in Moscow." In contrast, it appears the Soviets were not at all excited by this development, considering a large number of ALCMs a much greater threat than a smaller number of B-1s. Tass commented that "the implementation of these militaristic plans has seriously complicated efforts for the limitation of the strategic arms race." Military leaders were generally happy with the decision, however. Alexander Haig, then commanding NATO, described the ALCM as an "attractive alternative" to the B-1. French General Georges Buis stated "The B-1 is a formidable weapon, but not terribly useful. For the price of one bomber, you can have 200 cruise missiles."

Flight tests of the four B-1A models continued through 1985.

File:B-1b underside 1982.jpg

A B-1A in flight showing its underside, 1981.

The first B-1A was scrapped at the Rome Air Development Center, New York. The second (s/n 74-159) flew for the subsequent B-1B program, but crashed on August 29, 1984. The other two B-1As survived. The third prototype (s/n 74-160) is on display at Wings Over the Rockies in Denver, Colorado. The last B-1A (s/n 74-174) also served in the B-1B program. It was on display at the National Museum of the United States Air Force near Dayton, Ohio for many years before moving to the Strategic Air and Space Museum in Ashland, Nebraska. This aircraft has conventional ejection seats and other features distinctive to the B-1B variant instead of the B-1A.

Shifting priorities

It was during this period that the Soviets, also acting in proxy through Cuba, started to exert themselves in several new theaters of action, in particular the Cuban support in Angola starting in 1975 and the Soviet invasion of Afghanistan in 1979. The US strategy to this point was containment and a conventional and nuclear war in Europe, which almost all military planning had been focussed on. These newer actions revealed that military was simply incapable of supporting any sort of effort outside these narrow confines.

The Army responded by accelerating its Rapid Deployment Force concept, but suffered from major problems with airlift and sealift capability. While gaming a USSR-led invasion of Iran from Afghanistan, then considered (incorrectly) to be a major Soviet goal, it was discovered that only small numbers of units could be in the field in anything close to a week. In order to slow an advance while this happened they relied on air power, but critically the Iran-Afghanistan border was outside the US Navy's range, leaving this role to the Air Force. They, in turn, had limited capability to offer ground support in many areas that were outside of the range of friendly airbases. Although the B-52 had the range to support on-demand global missions, the B-52's long runway requirements dramatically limited the forward basing possibilities. In real-world scenarios the capabilities of this force against any given potential target was limited, something the B-1 would be better prepared to handle due to its better takeoff performance and range.

During the 1980 presidential campaign, Ronald Reagan campaigned heavily on the platform that Carter was "weak on defense", using the cancellation of the B-1 program as a prime example, a theme he continued using into the 1980s. During this time Carter's defense secretary, Harold Brown, announced the stealth bomber project, apparently implying that this was the reason for the B-1 cancellation. Brown later denied this claim, stating Carter was simply opposed to any military buildup. Although Reagan's primary attack on Carter's decision was now rendered moot, he immediately changed his complaint saying that Carter was giving away secrets and politicizing the Pentagon, charges that led to a round of sparring between Brown and Reagan in the press. Interestingly, it was Brown that had led the original AMSA program, but later came to prefer the cruise missile after taking the job of Defense Secretary in 1977.

B-1B program

On taking office, Reagan was faced with the same decision as Carter before; whether to continue with the B-1 for the short term, or to wait for the development of the ATB, a much more advanced aircraft. Air Force studies suggested that the existing B-52 fleet with ALCM would remain a credible threat until 1985, as it was predicted that 75% of the B-52 force would survive to attack its targets. After this period the introduction of the SA-10 missile, MiG-31 interceptor and the first Soviet AWACS systems would make them increasingly vulnerable.

During the FY81 budget funds were given to a new study for a bomber for the 1990s time-frame. These studies led to the Long-Range Combat Aircraft (LRCA) project which compared the B-1, F-111 and ATB as possible solutions. An emphasis was placed on the design being multi-role, as opposed to a purely strategic weapon. Reagan decided the best solution was to purchase both the B-1 and ATB, and this eventually led to Reagan's 2 October 1981 announcement that a new version of the B-1 was being ordered to fill the LRCA role.

Numerous changes were made to the design to better fit it to real-world missions, resulting in the new B-1B. These changes included a reduction in maximum speed, which allowed the variable-aspect intake ramps to be replaced with fixed ramps of considerably reduced complexity. This also allowed the newer design to be made more stealthy, allowing the compressor face of the engines, a major radar reflector, to be partially hidden. Low-altitude speed was somewhat improved, from about Mach 0.85 to 0.95. This left the B-1B with the capability for speeds of about Mach 1.25 "at altitude", a reduction from the B-1A's Mach 2 performance. In order to deal with the introduction of the MiG-31 and other aircraft with look-down capability, the B-1B's electronic warfare suite was significantly upgraded. These changes, along with rampant inflation, dramatically increased the prices to about $200 million per unit.

B-1B banking during a demonstration in 2004.

Opposition to the plan was widespread within Congress. Critics pointed out that many of the original problems with the concept remained. In particular it seemed the B-52 fit with electronics similar to the B-1B would be equally able to avoid interception, as the speed advantage of the B-1 was now minimal. It also appeared that the "interim" time frame served by the B-1B would be less than a decade, being rendered obsolete shortly after introduction by the much more capable ATB design. The primary argument in favor of the B-1 was its large conventional payload, and that its takeoff performance allowed it to operate with a credible bombload from a much wider variety of airfields. The debate remained rancorous. But the Air Force very astutely spread production subcontracts across many congressional districts, making the aircraft very popular on Capitol Hill.

The first production model of the revised B-1B first flew in October 1984, and the first B-1B, "The Star of Abilene", was delivered to Dyess Air Force Base, Abilene, Texas, in June 1985, with initial operational capability on October 1, 1986. The final B-1B was delivered May 2, 1988.

Although officially nicknamed the "Lancer", B-1 crews almost never refer to the aircraft by this name. Crews prefer to call the B-1 the "Bone". Origins of the "Bone" nickname are disputed, but appear to stem from an early newspaper article about the aircraft wherein its name was phonetically spelled out as "B-ONE". Crews, who generally felt the "Lancer" moniker was unappealing, quickly latched onto the "Bone" nickname.

Technological features

B-1B at RIAT 2004.

The B-1 has a blended wing body configuration, along with canards and variable-geometry wing design and turbofan engines, to improve range and speed with enhanced survivability. Forward wing settings are used for takeoff, landings and high-altitude maximum cruise. Aft wing settings are used in high subsonic and supersonic flight, enhancing the B-1's performance. The wings of the B-1B originally were cleared for use at settings of 15, 25, 55, and 67.5 degrees. The 45-degree setting was later cleared in 1998–1999.

The length of the aircraft presented a serious flexing problem due to air turbulence at low altitude. To alleviate this, Rockwell included small canards near the nose on the B-1. An accelerometer would actuate the canards automatically to counteract turbulence and smooth out the ride. There was some suggestion that this system might be useful on commercial airliners as well, but, to date, no airliner has made use of this system, but Airbus's A340-500 and A340-600 do actuate the elevators to alleviate bending stresses on the fuselage.

Unlike the B-1A, the B-1B made no attempt at Mach 2+ speeds. Its maximum speed at altitude is Mach 1.25 (about 950 mph or 1,330 km/h), but its low-level speed increased to Mach 0.95 (about 700 mph/1,118 km/h). Technically, the current version of the aircraft can exceed its speed restriction, but not without risking potential damage to its structure and air intakes. The B-1A's engine was modified slightly to produce the F101-102, with an emphasis on durability, and increased efficiency. The core of this engine has since been re-used in several other engine designs, including the F110 which has seen use in the F-14 Tomcat, South Korean F-15 Eagles and most recent versions of the F-16 Fighting Falcon. It is also the basis for the non-afterburning F118 used in the B-2 Spirit bomber and the U-2S. However its greatest success was forming the core of the extremely popular CFM56 civil engine, which can be found on some versions of practically every small-to-medium sized airliner.

B-1B Cockpit at night.

The B-1's offensive avionics include the Westinghouse (now Northrop Grumman) AN/APQ-164 forward-looking offensive passive electronically scanned array radar set with electronic beam steering (and a fixed antenna pointed downward for reduced radar observability), synthetic aperture radar, ground moving target indicator (MTI), and terrain-following radar modes, Doppler navigation, radar altimeter, and an inertial navigation suite. From 1995 on, the B-1B Block D upgrade added a Global Positioning System receiver.

B-1B releasing bombs and ejecting a MJU 23 decoy flare.

The B-1's defensive electronics include the Eaton AN/ALQ-161 radar warning and defensive jamming equipment, linked to a total of eight AN/ALE-49 flare dispensers located on top behind the canopy, which are handled by the AN/ASQ-184 avionics management system. The AN-ALE 49 has a capacity of 12 MJU 23 A/B flares each. The MJU 23 A/B flare is one of the world's largest infrared countermeasure flares having a gross weight of ~1170 g. The cylindrical pellet from Magnesium/Teflon/Viton has a net weight of ~1470 g. The Plans for a defensive systems upgrade program (DSUP) were cancelled for budgetary reasons. The B-1 has also been equipped to carry the ALE-50 Towed Decoy System. The Lancer has an additional Doppler tail-warning radar to detect aircraft or missiles approaching from the rear.

Also aiding the B-1's survivability is its relatively low radar cross-section (RCS). Although not technically a stealth aircraft in a comprehensive sense, thanks to the aircraft's structure, serpentine intake paths, and use of radar-absorbent material, its RCS is about 1/50th that of the B-52 (probably about 26 ft²), although the Lancer is not substantially smaller in mass than the Stratofortress.

File:100 0340.jpg

A B-1B at the 2006 Miramar Airshow.

The B-1 has been upgraded since production through the Conventional Mission Upgrade Program. This multi-stage program added a new MIL-STD-1760 smart-weapons interface that enables the use of the Joint Direct Attack Munition and other precision-guided conventional weapons, such as the Wind-Corrected Munitions Dispenser (WCMD), the AGM-154 Joint Standoff Weapon (JSOW), and the AGM-158 JASSM (Joint Air to Surface Standoff Munition). Future precision munitions include the GBU-39 Small Diameter Bomb.[1] These and other improvements are intended to ensure that the B-1 will be viable through approximately 2020. In addition, the Air Force has recently announced a program to keep the aircraft flying until at least 2040.

Operational service

The USAF Strategic Air Command had B-1 Lancers in service from 1986 through 1992, when SAC was re-organized out of existence. During that time the "Bone" was on limited alert, and the backbone of SAC's alert bombers remained B-52H models. In late 1990 engine fires in two Lancers caused the grounding of the fleet. The cause was traced back to problems in the first-stage fan. Aircraft were placed on "limited alert", meaning they were grounded unless a nuclear war broke out. They were returned to duty one-at-a-time starting in January 1991 as they were inspected and repaired. It was not until mid-April that the fleet was once again declared airworthy.

Originally designed strictly for nuclear war, the B-1's development as an effective conventional bomber was delayed until the 1990s. By 1991, the B-1 had a fledgling conventional capability, forty of them able to drop the 500 lb Mk-82 General Purpose (GP) bomb, although mostly from low altitude. Although cleared for this role, the problems with the engines precluded their use in Operation Desert Storm.

After the absorption of Strategic Air Command (SAC) into Air Combat Command in 1992, the B-1 began to truly develop conventionally. A key part of this development was the start-up of the B-1 Weapons School Division, also in 1992. By the mid-1990s, the B-1 could employ GP weapons as well as various CBUs. By the end of the 1990s, with the advent of the "Block D" upgrade, the B-1 boasted a full array of guided and unguided munitions. This development has continued through the present.

Crew members transfer a 2,000 pound GBU-31 Joint Direct Attack Munition (JDAM) to a lift truck for loading onto a B-1B Lancer on March 29, 2007, in Southwest Asia in support of combat operations.

Operationally, the B-1 was first used in combat in support of operations against Iraq during Operation Desert Fox in December 1998, employing unguided GP weapons. B-1s have been subsequently used in Operation Allied Force (Kosovo) and most notably in Operation Enduring Freedom in Afghanistan and the 2003 invasion of Iraq. In both conflicts, the B-1 employed its full array of weapons, most notably the GBU-31, 2000-pound Joint Direct Attack Munition (JDAM). During OEF, the B-1 improved its mission capable rate to 79%. The B-1 continues to be used in combat to the present (2006). The most recent addition to its arsenal is the GBU-38, a 500 lb JDAM. The use of the GBU-38 reduces undesired collateral damage and is very useful in urban Close Air Support.

The B-1 now fills an important niche in the Air Force inventory. It is worth noting that the project finished on budget, and has higher survivability and speed when compared to the older B-52, which it was intended to replace. With the arrival of limited numbers of B-2s in the 1990s and the continuing use of B-52s, its value has been questioned. However, the capability of a high-speed strike with a large bomb payload for time-sensitive operations is useful, and no new strategic bomber is on the immediate horizon.

The B-1 holds several world records for speed, payload and distance. The National Aeronautic Association recognized the B-1B for completing one of the 10 most memorable record flights for 1993.

Partial retirement

A B-1B flying over the Pacific.

A total of 100 front-line aircraft were produced at a cost of over $200 million each. After several accidents that resulted in the loss of aircraft (and in some cases the death of crew members), 93 bombers remained by the turn of the century.

In 2003 the USAF decided to retire 33 of the B-1Bs to concentrate its budget on maintaining availability of the remaining aircraft, although in 2004 a new appropriations bill called for some of the retired aircraft to return to service. In 2004, the USAF returned seven of the mothballed bombers to service, giving a total force of 67 aircraft, with the rest cannibalized for spares. Five of the seven that were brought back to service went to Dyess AFB in Texas, one to Ellsworth AFB in South Dakota, and another to Edwards AFB in California. In 2005, The Pentagon announced the closing of Ellsworth AFB and the transfer of all operational B-1s to Dyess AFB. However, on August 26, 2005, it was announced that Ellsworth AFB would remain open; thus, no transfer of Ellsworth's B-1s would occur.

Variants

B-1R

The B-1R is a proposed replacement for the B-1B fleet. Boeing's director of global strike integration, Rich Parke, was first quoted about the "B-1R" bomber in Air Force Magazine. Parke said the B-1R (R stands for "regional") would be a Lancer with advanced radars, air-to-air missiles, and Pratt & Whitney F119 engines (originally developed for the F-22 Raptor). Its new top speed — Mach 2.2 — would be purchased at the price of a 20% reduction of the B-1B's combat range. This proposal would involve modifying existing aircraft. The FB-22 and YF-23-based design are alternative proposals.

The B-2 has proven itself in the "limited strike" role, able to penetrate any current air defense system and deliver conventional bombs with impunity. The role of "fleet in being" is ably served, and there appears to be no reason to maintain the B-52s for this purpose alone. This leaves the "bomb truck" duty as the B-52's primary role that is not currently filled by other aircraft.

Other changes in the nature of modern air warfare have also come into play. Missiles like the AIM-120 and AIM-9X so improve on older designs that the primary determinant of air combat success appears to be having the best radars and display systems – the aircraft that can detect, lock-on and shoot first will almost certainly win an engagement, even, to a limited degree, against aircraft behind it. The idea of a "missile truck" for air-to-air combat has long been a dream of fighter designers, notably in the U.S. Navy (in the form of the canceled F6D Missileer), but these designs were always found to be seriously flawed when the missiles turned out to have disappointing real-world performance compared to their paper predictions. This era appears to be at an end, and the concept of a long-range heavy missile-firing air-to-air platform appears to be a practical possibility, even for a large and unmaneuverable aircraft.

B-1R concept.

B-1R concept.

Boeing's proposal appears to modify the B-1B into a design able to serve these two purposes. For the bomb-truck role Boeing proposes the modification of existing external hardpoints to allow them to carry multiple conventional warheads, dramatically improving overall warload. For the air-to-air role, both defensive and offensive, they propose to add active electronically-scanned array radar and allow some of the hardpoints to carry AA missiles. Even with its somewhat reduced range as compared to the original B-1B, its fuel capacity remains quite large. This would allow it to escape from unfavorable air-to-air encounters by simply running away; there are few enough aircraft capable of Mach 2.2 performance in general, and those that are deployed can maintain these speeds for very short periods of time.

In general terms the B-1R most closely resembles the original F-111 concept, as opposed to a pure bomber role. However it would be able to carry out these missions at ranges even greater than the F-111.

Upgrades

Conventional Mission Upgrade Program

The Conventional Mission Upgrade Program (CMUP) will enhance the airplane's effectiveness as a conventional weapons carrier. Capability will be delivered in blocks attained by hardware modifications and software updates.

• Block A: Standard design of the B-1B with the capability to deliver non-precision Mk-82 500 lb gravity bombs. Before CMUP all B-1Bs were designated as "Block A" models.
• Block B: Improved Synthetic Aperture Radar, as well as some upgrades to the Defensive Countermeasures System. This upgrade reached the field in 1995.
• Block C: "Enhanced Capability" provided for delivery of up to 30 Cluster Bomb Units (CBUs) per sortie. The upgrade consists of modification for B-1B bomb module from the original configuration of 28 500 lb bombs per unit to 10 1,000 lb cluster bombs per bomb rack. The modifications were made to 50 bomb racks. This capability was completed in August 1997.
• Block D: "Near Precision Capability" gives B-1 aircrews increased abilities to accurately put bombs on target with improved weapons and targeting systems, as well as giving them advanced secure communications capabilities. The first part of the electronic countermeasures upgrade, addition of Joint Direct Attack Munitions (JDAM) and anti-jam radios are also included.[2]
• Block E: This upgrade covers improvements to the avionics computers. This package also incorporates the Wind-Corrected Munitions Dispenser (WCMD), the Joint Standoff Weapon (JSOW) and the Joint Air-to-Surface Standoff Missile (JASSM), substantially improving the bomber's capability. Upgrades were completed in Sept. 2006.[3]
• Block F: The Defensive Systems Upgrade Program (DSUP) improves the aircraft's electronic countermeasures and jamming capabilities. This includes the Towed Decoy System (TDS). Upgrades were canceled in December 2002 due to cost overruns and schedule slips.[4]
• Block G: "Standoff Capability" upgrades JSOW & JASSM integration. Also provides computer and WCMD upgrades with a DSUP integration upgrade.

Crashes and major malfunctions

Since 1984, 17 people have been killed in B-1 crashes (as of 2001).

• On August 29, 1984, a B-1A stalled and crashed while performing minimum control speed tests at a low altitude. The crew used the escape capsule to leave the plane, but the parachute deployed improperly and the pilot, Doug Benefield, was killed on impact.

• In September 1987, a B-1B (84-0052), from the 96th Bomb Wing, 338th Bomb Squadron, Dyess AFB crashed near LaJunta Colorado, while flying in a low level training route. This was the only B-1B crash with six crewmembers in the aircraft. Three crewmembers survived; tragically, the other three crewmembers perished.

• In October 1988, a B-1B (85-0063), from the 96th Bomb Wing, 337th Bomb Squadron, Dyess AFB crashed near Tye, Texas while flying in the Dyess AFB traffic pattern. All four crewmembers successfully ejected from the aircraft.

• In November 1988, a B-1B (85-0076), from the 28th Bomb Wing, 37th Bomb Squadron, Ellsworth AFB crashed short of the runway at Ellsworth AFB. All four crewmembers successfully ejected from the aircraft.

• In October 1990, a B-1B (86-0128), from the 384th Bomb Wing, 28th Bomb Squadron, McConnell AFB, while flying in a low level training route in eastern Colorado, lost an entire engine (although the crew was unaware the engine had actually departed the aircraft). It was later determined the engine had suffered catastrophic failure, in which engine blades cut through the engine mounts, causing the engine to detach from the aircraft.

• In December 1990, a B-1B (83-0071), from the 96th Bomb Wing, 337th Bomb Squadron, Dyess AFB, Texas experienced a #3 engine fire, which could not be extinguished with either the main or reserve fire-extinguisher systems. Coupled with the October 1990 engine incident led to a 50+ day grounding of the entire B-1B fleet. The problem was eventually traced back to problems in the first-stage fan, and the entire fleet of engines were subsequently modified.

• In November 1992, a B-1B (86-0106) from the 7th Bomb Wing, 337th Bomb Squadron, Dyess AFB, Texas, while flying in a low level training route in southern Texas crashed near the Texas-Mexico border. Tragically, all four members of the crew were killed. The cause was attributed to pilot error.

• In September 1997, a B-1B (85-0078) from the 28th Bomb Wing, 37th Bomb Squadron, Ellsworth AFB, South Dakota, flying in the Powder River Military Operating Area approximately 80 miles north of Rapid City, South Dakota, crashed. Tragically, all four members of the crew were killed. The cause was attributed to pilot error.

• In February 1998, a B-1B (84-0057) from the 7th Bomb Wing, 9th Bomb Squadron, Dyess AFB, Texas was lost over Kentucky when a fire in the cockpit instrument panel shut down the plane's power. All four crew members were able to eject and were rescued safely. In response to a warning light on the #3 engine, the crew took action to shut down the fuel pumps to that engine. However, a panel electrical short caused a fire, which shut down fuel to all engines, and prevented them from being restarted. "[T]he uncommanded shutdown of the three engines removed all hydraulic and electrical power from the aircraft, preventing a restart of the engines and controlling the aircraft", noted Col. David A. Shunk.

B-1B emergency landing in 2006.

• In December 2001, a B-1B (86-0114) from the 28th Bomb Wing, 37th Bomb Squadron, Ellsworth AFB, South Dakota, was lost over the Indian Ocean. All four crewmembers successfully ejected and were subsequently rescued. The bomber (of the 28th Bomb Wing, designated ICECUBE 44) was approximately 100 miles north of Diego Garcia, where it had departed from, flying en route to a long-range combat mission over Afghanistan, when the crew declared an in-flight emergency. Details remain classified. The pilot, Capt. William Steele, attributed the crash to "multiple malfunctions" causing the bomber to go "out of control". Further information from maintenance specialists related the aircraft mishap to the aircrew experiencing electrical bus failures that contributed to an instrument blackout affecting both primary and backup instruments. It was also rumored that the aircraft at the time the aircrew ejected was not in level flight but inverted and quickly heading nose down towards the Indian Ocean. With no visual reference available to the aircrew of level flight, the four members ejected safely. Because of the depth of the water in which the aircraft crashed, the structural data collector (SDC) or "Black Box" was not recovered from the wreckage and the nature of the cause was not positively determined. The aircraft had recently returned from Ellsworth AFB from a routine Phase Inspection, and was on its first combat mission after returning to Diego Garcia. Hostile fire was ruled out as a cause for the crash. The crew spent two hours in the water before being rescued by a launch from the USS Russell. This was the first B-1B to be lost in combat operations since the model became operational in 1986.

• In May 2006, a B-1B (86-0132) from the 7th Bomb Wing, 9th Bomb Squadron, Dyess AFB, Texas, upon recovery from an 11-hour ferry flight to Diego Garcia landed "gear-up". The Air Force investigation concluded that the pilots "forgot to lower the landing gear". A resulting fire was quickly extinguished and the crew escaped through the top hatch unharmed. Four days later the aircraft was raised and its landing gear deployed. The aircraft damage was estimated at nearly $8 million.

Operators

A 28th Bomb Wing B-1B Lancer sits on the ramp in the early morning at Ellsworth Air Force Base, South Dakota.

• United States
  • U.S. Air Force
    • 96th Bombardment Wing, Dyess Air Force Base, Abilene, Texas (1984-1992)
      • 4018th Combat Crew Training Squadron (CCTS) (1984-1985)
      • 338th Bombardment Squadron (1985-1992)
      • 337th Bombardment Squadron (1985-1992)
    • 7th Bomb Wing, Dyess AFB, Abilene, Texas
      • 9th Bomb Squadron
      • 28th Bomb Squadron
    • 28th Bomb Wing, Ellsworth AFB, Rapid City, South Dakota
      • 34th Bomb Squadron
      • 37th Bomb Squadron
      • 77th Bombardment Squadron (1986-1995, 1996-2001)
    • 319th Bombardment Wing, Grand Forks Air Force Base, Grand Forks, North Dakota (1986-1994)
      • 46th Bombardment Squadron (1986-1994)
    • 384th Bombardment Wing, McConnell AFB, Wichita, Kansas (1987-1994)
      • 28th Bombardment Squadron (1987-1994)
    • 366th Wing, Mountain Home Air Force Base, Mountain Home, Idaho (1994-2002)
      • 34th Bomb Squadron, Ellsworth Air Force Base (1994-1997)
      • 34th Bomb Squadron, Mountain Home Air Force Base (1997-2002)
    • 184th Bomb Wing, Kansas Air National Guard, McConnell AFB, Wichita, Kansas (1994-2002)
      • 127th Bomb Squaron, Kansas Air National Guard (1994-2002)
    • 116th Bombardment Wing, Georgia Air National Guard, Robin AFB, Macon, Georgia (1995-2002)
      • 128th Bombardment Squadron, Georgia Air National Guard (1995-2002)
    • 53d Wing, Eglin AFB, Florida
      • 337th Test and Evaluation Squadron, Dyess AFB, Texas
    • 57th Wing, Nellis AFB, Nevada
      • B-1 Division, US Air Force Weapons School, Ellsworth AFB, South Dakota (1992-2002)
      • 77th Weapons Squadron, USAF Weapons School, Dyess AFB, Texas

Specifications (B-1B)

B-1B orthographic projection.

General characteristics

• Crew: 4: aircraft commander, copilot, offensive systems officer and defensive systems officer
• Airfoil: NA69-190-2

Performance

• Thrust/weight: 0.37

Armament

• Locations:
  • 6 external hardpoints for an additional 59,000 lb (27,000 kg) of ordnance (use for weapons currently restricted by START I treaty)
  • 3 internal bays for 75,000 lb (34,000 kg) of ordnance.
• Options:
  • Bombs:
    • 84× Mk-82AIR inflatable retarder general purpose bombs
    • 81× Mk-82 conical general purpose bombs
    • 84× Mk-62 Quickstrike naval mines
    • 8× Mk-65 naval mines
    • 30× CBU-87/89/CBU-97 Cluster Bomb Units (CBU)
    • 30× CBU-103/104/105 WCMD
    • 24× GBU-31 JDAM GPS guided bombs (both Mk-84 general purpose and BLU-109 penetrating bombs)
    • 17x GBU-38 JDAM GPS guided bombs (Mk-82 general purpose warhead)
    • 24× Mk-84 general purpose bombs
    • 96x or 144× GBU-39 Small Diameter Bomb GPS guided bombs (96 if using four-packs, 144 if using six-packs) (this capability has not yet been fielded on the B-1)
  • Missiles:
    • 24× AGM-158 JASSM
    • 12× AGM-154 JSOW
  • Fuel: One or more of the three internal weapons bays can be configured to carry a 10,000 gallon (38,000 L) fuel tank instead of weapons in that bay

Avionics

• 1× Westinghouse AN/APQ-164 forward-looking offensive passive phased-array radar
• 1× Eaton AN/ALQ-161 radar warning and defensive jamming equipment
• 1× AN/ASQ-184 defensive management system

Popular culture

• Footage shot from the tail of the fourth B-1A prototype flying over the desert appears in Godfrey Reggio's film Koyaanisqatsi, pictured here
• The author Dale Brown frequently features B-1 and B-52 bombers in his books.
• The unofficial 1983 James Bond film Never Say Never Again features a cruise missile launch from a B-1 bomber (although a sequence in which cruise missiles are loaded onto the B-1 was filmed with a Concorde SST substituting for the B-1's undercarriage). [5]
• In the Larry Niven and Jerry Pournelle science fiction novel Footfall, the President is taken to safety at NORAD aboard a B-1 bomber, during an alien invasion.
• In the Tom Clancy book Debt of Honor, B-1s are used to test the Japanese air defenses, where one was shot down. They were also used in a demonstration against the Indian Navy, where five of them overflew an Indian fleet at low altitude, slightly damaging the fleet's electronics.
• In the 1985 movie Real Genius, an aircraft that looks like the fourth prototype B-1A, with desert pattern camouflage and extended spine to the tail, is used as a platform for an airborne laser. The aircraft is noted to be flying at "flight level 650", or five thousand feet above its stated service ceiling.

External links

• B-1 System Program Office Public web site
• B-1B page on Boeing.com
• B-1B U.S. Air Force Fact Sheet
• B-1 page on NASA Langley site
• B-1 page on GlobalSecurity.org
• B-1B Lancer U.S. Air Force history article
• B-1 Lancer profile on CombatAircraft.com
• B-1A on TheXHunters.com

Related content

Related development

• Boeing 2707
• FB-111

Aircraft of comparable role, configuration, and era

• Tupolev Tu-160
• Tupolev Tu-22M

Related lists

• List of bomber aircraft
• List of military aircraft of the United States
• List of active United States military aircraft