Apollo 1

**Apollo 1**
Mission Insignia

Planned Mission
Mission Name:	Apollo 1 (AS-204)
Call Sign:	Command module: Apollo 1
Number of Crew:	3
Planned Launch:	February 21 1967 Kennedy Space Center LC 34
Planned Apogee:	~300 km
Planned Perigee:	~230 km
Planned Period:	~89.7 m
Planned Inclination:	~31°
Planned Landing:	March 7 1967 Atlantic Ocean N of Puerto Rico planned carrier USS Essex (CV-9)
Planned Duration:	14 days
Planned Number of Orbits:	~200
Mass:	CSM 20,412 kg
Crew Picture
Apollo 1 crew portrait (L-R: Grissom, White and Chaffee) Apollo 1 crew portrait (L-R: Grissom, White and Chaffee)
Apollo 1 Crew

Apollo One is the official name given retroactively to the Apollo/Saturn 204 (AS-204) spacecraft, destroyed by fire during a training exercise on January 27 1967, at Pad 34 (Launch Complex 34 at Cape Canaveral) atop a Saturn IB rocket. Its crew were the astronauts selected for the initial Apollo program mission and all three died in the accident: Command Pilot Virgil I. Grissom, Senior Pilot Ed White, and Pilot Roger B. Chaffee.

Crew

Virgil Grissom (flew on Mercury 4 & Gemini 3), Command Pilot
Ed White (flew on Gemini 4), Senior Pilot
Roger B. Chaffee (never flew in space), Pilot

Backup crew

April - December 1966
- James McDivitt, Command Pilot
- David Scott, Senior Pilot
- Rusty Schweickart, Pilot

This crew became the crew of Apollo 9.

December 1966 - January 1967
- Walter Schirra, Command Pilot
- Donn Eisele, Senior Pilot
- Walter Cunningham, Pilot

This crew became the crew of Apollo 7.

The mission

AS-204 was to be the first manned flight of a Block I Apollo capsule to Earth orbit, launched on a Saturn 1B. It was to take place sometime in the first quarter of 1967, having already missed a target date of the last quarter of 1966. The purpose of the flight was to test "launch operations, ground tracking and control facilities, and the performance of the Apollo-Saturn" [1]. The mission would have lasted up to two weeks. No launch was planned for January 27, 1967; instead, the plan was for a launch simulation that would test whether the Apollo spacecraft would operate nominally on internal power, detached from all cables and umbilicals. If the spacecraft had passed this and subsequent tests, it might have been ready to fly in February 1967.

If successful, Apollo 1 would have been followed by two other Apollo flights in the summer and late autumn of 1967. The first of these would have launched a Block II Apollo CSM on a Saturn 1B, and an unmanned LM on a second Saturn 1B, both to low earth orbit to be followed by CSM-LM rendezvous and docking. The second would have involved launch of CSM and LM on a Saturn V to high earth orbit. All of these missions were cancelled following the Apollo 1 fire; their mission objectives, in a somewhat different form, were satisfied by Apollo 7, Apollo 9, and Apollo 8.

The test

The "plugs-out" test planned for January 27, 1967, was never actually carried out, as the fire took place before connections to the Apollo-Saturn were withdrawn. Grissom, White and Chaffee, fully suited, entered the Apollo capsule at 1:00 pm, were strapped into their seats and sealed in. There were immediate problems: a strange sour smell in the air in Grissom's suit, an alarm about high oxygen flow, and faulty communications between the crew, the control room, the operations and checkout building, and the complex 34 blockhouse. Communications problems put the launch simulation on hold at 5:40 pm. The countdown had still not been restarted at 6:30 pm.

The accident

The Apollo 1 Command Module was a "Block I" design, built for spaceflight but never intended for a trip to the moon, as it lacked the necessary docking equipment.

Immediately prior to the accident, the crew members were reclining in their horizontal couches, running through a checklist of things they would do in space while a communication system problem was being fixed. Suddenly, a voice (now believed to be Chaffee's, as his was the only clear channel) was heard over the COM link, "We've got fire in the cockpit." A few seconds later the transmissions ended with a cry of pain. On the television monitors, Ed White was seen to be attempting to open the hatch. However, the two-piece hatch was of a design which required that the crew undo several bolts in order to remove the inner section, and was impossible to open quickly. Furthermore, the inner portion of hatch opened inwards, an intentional design feature intended to exploit the cabin's air pressure in order to further tighten the hatch seal during spaceflight. The hot gases produced by the fire held the hatch shut, and within a few seconds the air pressure had risen enough to prevent the crew from escaping (and in fact the air pressure rose so high as to rupture the capsule).

Cause

The fire is believed to have been caused by a spark somewhere in the capsule's 30 miles (50 km) of wiring. Due to the pure oxygen inside the capsule (which was at a pressure of 15 psi or 100 kPa) the fire was quickly out of control. The Apollo 204 Review Board determined that a silver-plated copper wire running through an environmental control unit near the command module pilot's couch had become stripped of its insulation and abraded by repeated opening and closing of an associated access door. This weak point in the wiring also happened to pass near a junction in an ethylene glycol/water cooling line, which had developed a leak. The electrolysis of ethylene glycol solution with the anode made of silver resulted in a violent exothermic reaction that ignited the ethylene glycol mixture, which in turn was able to burn in the atmosphere of pure pressurized oxygen.[2] A similar March 1961 incident had previously claimed the life of Soviet cosmonaut trainee Valentin Bondarenko when the pure oxygen atmosphere in the isolation chamber he had been occupying had caught fire, a calamity the USSR had, for years, concealed from the public. The NASA investigation found that a bar of aluminum can burn like wood in a pure oxygen atmosphere. It also found substandard wiring in the craft and a missing socket wrench that was ruled out as the fire's cause. Many items on board were flammable, and flammable velcro had been applied to the walls of the craft to secure items in weightless conditions.

The fire

The fire spread quickly and within seconds was out of control. As a result of toxic smoke and malfunctioning gas masks, ground crew needed five minutes to open the hatch and suppress the flames. The fire had melted the astronauts' space suits and the air lines which connected them to the capsule's life support systems. Grissom's and White's suits were found to have fused together. It was evident from how the corpses lay that they had tried to get out, but they never had a chance. Ed White, who was supposed to open the hatch, was partway out of his harness and had apparently made an effort to escape. The procedure would have had Grissom lower White's headrest, and White proceed to unlatch over 12 bolts to release the hatch. Indeed, even if he were to accomplish that, the internal pressure had risen so high that the inward-opening hatch could not have been opened. Chaffee's job was to begin shutting down the spacecraft and maintain communications with ground control. He was found dead still strapped into his right hand seat. Only 17 seconds from the first call of "Fire!", all three were dead.

It was later confirmed that the crew had actually died of smoke inhalation rather than burns. According to the Report of the Apollo 204 Review Board — Appendix D Panel 11, (link provided below), Grissom suffered third degree burns on 36% of his body (1st, 2nd and 3rd degree burns covered 60% of his body) and his spacesuit was 70% destroyed. White suffered third degree burns on 40% of his body (1st, 2nd and 3rd degree burns covered 48% of his body) and his spacesuit was 25% destroyed. Chaffee suffered third degree burns on 23% of his body (1st, 2nd and 3rd degree burns covered 29% of his body) and his spacesuit was 15% destroyed.

The company that produced the command module, North American Aviation, had originally suggested that the hatch open outward and be able to open with explosive bolts in case of emergency. They had also suggested that the atmosphere be an oxygen/nitrogen mixture, like on the earth's surface. NASA didn't agree, arguing that the hatch could be accidentally opened (this is what caused Liberty Bell 7 — ironically, piloted by Grissom — to sink into the ocean during splashdown recovery operations; Grissom himself argued that the hatch should be stronger, more secure, and harder to open), and that if too much nitrogen were released into the atmosphere, the astronauts would pass out and then die. They also argued that since a pure oxygen atmosphere was used safely in Mercury and Gemini, it should be safe to use for Apollo. Furthermore, such a design saved weight. After the fire, Apollo was grounded pending a redesign, with the following results:

The atmosphere would not be pressurized to 2 lbf/in² (14 kPa) above atmospheric pressure. It would consist of 60% oxygen and 40% nitrogen at sea-level pressure at launch, lowering to 5 kPa of pressure during launch, and gradually changing over to 100% oxygen during the first 24 hours of the trans-lunar coast.
The hatch would open outward, and be operable in less than ten seconds.
Flammable materials in the cabin were replaced with self-extinguishing materials.
Plumbing and wiring were covered with protective insulation.
1,407 wiring problems were corrected.
Nylon suits were replaced with coated glass fabric suits, which are much more difficult to ignite.

The naming of Apollo 1

When North American Aviation shipped Spacecraft CM-012 to Kennedy Space Center, it bore a banner proclaiming it "Apollo One" and Grissom's crew had received approval for an "Apollo 1" patch in June 1966, but NASA was planning to call that mission "AS-204." After the fire, the astronauts' widows asked that "Apollo 1" be reserved for the flight their husbands would never make. For a time, mission planners called the next scheduled launch "Apollo 2." Suggestions were made that the flights should be called "Apollo 1" (AS-204), "Apollo 1A" (AS-201), "Apollo 2" (AS-202), and "Apollo 3" (AS-203). Finally, the NASA Project Designation Committee approved "Apollo 4" for the first (unmanned) Apollo-Saturn V mission (AS-501), but declared that there would be no retroactive renaming of AS-201, -202, or -203. The Apollo 1 (AS-204) Saturn IB rocket was taken down from Launch Complex 34 and later reassembled at Launch Complex 37B. It was used to launch the Apollo 5 LM-1 into earth orbit for the first Lunar Module test mission.

Mission insignia

The center part of the insignia shows a command service module flying over the southeastern United States, with Florida, the launch point, prominent. The moon is seen in the distance, symbolic of the eventual goal of the program. A yellow border carries the mission and astronaut names, with another border including stars and stripes, trimmed in gold.

Memorial

Apollo 1 plaque that is attached to Launch Complex 34

Launch Complex 34, showing plaque on right rear post

While Launch Complex 34 has been essentially dismantled, the cement and steel-reinforced launch platform remains at the site. The platform bears two plaques for the 3 men who perished. One says:

LAUNCH COMPLEX 34

Friday, 27 January 1967
1831 Hours

Dedicated to the living memory of the crew of the Apollo 1:

U.S.A.F. Lt. Colonel Virgil I. Grissom
U.S.A.F. Lt. Colonel Edward H. White, II
U.S.N. Lt. Commander Roger B. Chaffee

They gave their lives in service to their country in the ongoing exploration of humankind's final frontier. Remember them not for how they died but for those ideals for which they lived.

File:Apollo 1 2nd plaque.png

Drawing of second Apollo 1 plaque that is attached to Launch Complex 34

The other says:

IN MEMORY OF THOSE WHO MADE THE ULTIMATE SACRIFICE SO OTHERS COULD REACH FOR THE STARS

AD ASTRA PER ASPERA
(A ROUGH ROAD LEADS TO THE STARS)

GOD SPEED TO THE CREW OF APOLLO 1

This plaque was featured in the film Armageddon.

In addition to both, a college classmate of one of the astronauts fashioned three granite benches, one for each member of the crew. The benches were installed in January 2005.

Each year the families of the Apollo 1 crew are invited to the site for a memorial, and the Kennedy Space Center Visitor Center offers a visit to the site for those who choose to take a special tour to the older launch sites that are on Cape Canaveral.

Three stars, Navi, Dnoces and Regor were named in honor of the crew. The names are "Ivan," "Second" and "Roger" spelled backwards. Ivan was Grissom's middle name and White was Edward H. White the Second. The crew used the stars to calibrate their equipment and, as a practical joke, recorded the names in official NASA documentation. The names eventually stuck as a posthumous honor.^[1]

In addition, craters on the Moon are named after the three astronauts.

References

^ http://www.hq.nasa.gov/alsj/a15/a15.postland.html Search the page for "regor" to find the reference.

Lattimer, Dick (1985). 'All We Did was Fly to the Moon. Whispering Eagle Press. ISBN 0961122803.

External links

[1] ttp://www.hq.nasa.gov/alsj/a15/a15.postland.html Search the page for "regor" to find the reference.

[1]